彩鋼瓦房頂?shù)墓羌芸芍^是建筑的核心，因此對于它的制作方法有著高標準、高要求，本文就為大家介紹了如何制作彩鋼瓦房頂?shù)墓羌埽Ｍ┕と藛T能夠認真閱讀。

The skeleton of the color steel tile roof is the core of the building, so there are high standards and requirements for its production method. This paper introduces how to make the skeleton of the color steel tile roof, and hopes that the construction personnel can read it carefully.

一、屋面

1、 Roofing

以山墻邊做起點，由左而右(或同右而左)依順序鋪設。然后片板安置完畢后，沿板下緣拉準線，每片依準線安裝，隨時檢查不使發生偏離。鋪設面以自攻螺絲，沿每一板肋中心固定于衍條上。

Starting from the side of the gable, lay it from left to right (or the same as right to left) in sequence. Then, after the plates are placed, draw the alignment line along the lower edge of the plate, install each plate according to the alignment line, and check at any time to avoid deviation. The laying surface is fixed on the extension strip along the center of each plate rib with self tapping screws.

二、收邊

2、 Edge trimming

屋面(含雨蓬)收邊料搭接處，須以鋁拉釘固定及止水膠。然后屋面收邊平板自攻螺絲頭及鋁拉釘頭，須以止水膠防止。收邊板施工固定方式，依其現場丈量需做變更時，以確認后制做圖為準。

The lap joint of roof (including canopy) edge material must be fixed with aluminum pull nails and water stop glue. Then the self tapping screw head and aluminum pull screw head of the roof trimming plate must be prevented by water stop glue. When the construction and fixing method of the edge plate needs to be changed according to its on-site measurement, the drawing shall prevail after confirmation.

三、固定方法

3、 Fixing method

濟南彩鋼瓦廠家建議排個固定座，以自攻螺絲固定于檁條左邊，然后于檁條彈墨線做基準線，接著固定同排固定座。接著塊板之肋部對準固定座之肋板，壓下卡入檢查是否扣合正確。然后將固定座短臂扣上塊已鋪好之面板陰肋，依前述方法施工，并調整。按上述順序鋪設，所剩空中樓閣間小于板寬一半時，僅用固定座短臂固定板片，其余空間以泛水收頭。如所剩空間大于板寬一半時，則以固定座固定板片，其超出部分裁除。

Jinan color steel tile manufacturer suggests to arrange a fixed seat, fix it on the left side of the purlin with self tapping screws, then snap the ink line on the purlin as the reference line, and then fix the fixed seat in the same row. Then align the rib of the plate with the rib of the fixed seat, press down and snap it in to check whether it is buckled correctly. Then buckle the short arm of the fixed base with a paved panel female rib, construct according to the above method, and adjust. Lay in the above order. When the remaining space between towers in the air is less than half the width of the slab, only fix the slab with the short arm of the fixed seat, and the rest of the space ends with flashing. If the remaining space is greater than half of the plate width, fix the plate with a fixed seat, and the excess part will be cut off.

彩鋼瓦屋面施工時如何進行防控

How to prevent and control the construction of colored steel tile roof

1、由于屋面坡度較大而且屋脊較多，在施工過程中對屋脊梁、檐口、老虎窗、匯(分)水線起止點等部位的標高控制;對于、坡度陰角線、坡度陽角線、檐口線、轉角點、匯(分)水線起止點的定位;腳手架搭拆時應注意施工，并確保施工正常進行。

1. As the roof slope is large and there are many ridges, the elevation control of roof ridge, cornice, dormer window, starting and ending points of catchment (Branch) waterline and other parts during the construction process; For the positioning of the starting and ending points of the internal corner line of the slope, the external corner line of the slope, the cornice line, the corner point and the catchment (Branch) waterline; Pay attention to the construction during scaffold erection and dismantling and ensure the normal construction.

2、屋面坡度較大，基層處理及掛瓦期間嚴格對工人做好技術交底，做好防護措施。

2. The roof slope is large, and the technical disclosure and protective measures shall be strictly carried out to the workers during the base treatment and tile hanging.

3、嚴格控制好彩鋼瓦的排列，陰角、陽角、端頭瓦以及與出屋面構筑物交界處處理好，謹防漏水。

3. Strictly control the arrangement of colored steel tiles, and handle the internal corners, external corners, end tiles and the junction with the roof structure to prevent water leakage.

4、彩鋼瓦廠家建議屋面周邊和預留孔洞部位設置護欄和網或其他防止墜落的防護措施。

4. The manufacturer of colored steel tiles suggests that guardrails and nets or other protective measures to prevent falling should be set around the roof and the reserved holes.

以上就是問題解答的相關內容了，希望能夠幫助到大家，如對這一問題還存在明顯疑問，都?xì)g迎關注我們網站http://www.liondatech.com并咨詢我們的工作人員，將竭誠為您服務。

The above is the relevant content of the question answer. I hope it can help you. If you still have any questions about this problem, you are welcome to follow our website http://www.liondatech.com And consult our staff, will serve you wholeheartedly.